火焰脉动在火灾领域相关研究进展

为研究火焰脉动在火灾领域相关研究进展，总结了不同燃料类型的火焰脉动形成机理，较为详细地介绍了火焰脉动现象研究中常用的脉动频率测量方法，列举了LDV、TDLAS、自由基团高频采集等新方法；介绍了池火脉动、射流/羽流气体火脉动在不同燃烧器尺寸，不同外部环境和不同燃料比等影响因素方面的研究内容与进展；对常见的3种不同的火焰脉动模型进行描述和归类；对火焰脉动的规律、机理等在火灾领域的早期识别和检测中的作用、特殊条件对于火焰脉动频率的影响和更加精细的火焰脉动模型的研究等方向提出展望。     

水平管内不同煤质煤尘爆炸火焰传播特性实验研究

为研究水平管道空间不同煤质煤尘爆炸火焰传播特性，选取褐煤、长焰煤、不粘煤、气煤4种煤尘，对爆炸火焰焰峰特性、火焰加速传播特性、火焰传播距离与持续时间展开研究。研究结果表明:褐煤在500 ms内焰峰的形状由尖锐向平滑再向钝化不断演变，长焰煤与不粘煤在375 ms时焰峰前端出现明显焰体分离现象，分析认为这与管体冷壁效应、空间尺度效应及空间氧气消耗直接相关；气煤在375 ms时焰峰出现大面积火焰碎纹，说明气煤爆炸火焰猛烈传播的持续时间相对较短，整体爆炸强度相对较弱；褐煤与长焰煤爆炸火焰存在2次间断性加速，分析认为这与管体空间受限、常温管壁散热、局部助燃氧气瞬间不足等因素有关；褐煤在爆炸后400～600 ms内火焰2次加速完全，火焰传播距离达740 mm，明显大于长焰煤、不粘煤与气煤，说明低变质褐煤爆炸火焰持续时间更长，火焰传播距离更远且传播更剧烈；虽然气煤火焰最远传播距离比长焰煤大30 mm，但由于气煤火焰在375 ms左右出现大片火焰碎纹，因此气煤整体的爆炸强度小于长焰煤。     

高效液相色谱-二极管阵列检测器测定邻苯二甲酸酯色谱条件优化

采用高效液相色谱-二极管阵列检测器对6种PAEs类物质进行测定,并对梯度洗脱条件、流速、检测波长等影响化合物色谱响应的关键参数进行优化。综合考虑样品测试效率、分析精度、实际样品中存在杂质干扰等因素,确定以乙腈-水为流动相进行梯度洗脱,洗脱0~11 min流动相乙腈-水梯度比例为50∶50,11 min后流动相调整为100%乙腈,各化合物均能完全分离;色谱分析流速为0.8 m L/min;PAEs的最佳吸收波长为225 nm。在优化的色谱条件下,6种PAEs的线性良好,相关系数均大于0.999 8,仪器检出限为0.08~0.12 mg/L,保留时间、峰面积的相对标准偏差分别为0.02%~0.60%、0.13%~0.86%。方法灵敏度较高,适合土壤等邻苯二甲酸酯含量较高基质样品的快速分析。     

Influence of vacuum degree on the effect of gas explosion suppression by vacuum chamber

In order to study the influence of vacuum degree on gas explosion suppression by vacuum chamber, this study used the 0.2 mm thick polytetrafluoroethylene film as the diaphragm of vacuum chamber to carry out a series of experiments of gas explosion suppression by vacuum chamber with the vacuum degree from −0.01 MPa to −0.08 MPa. The experimental results show that: under the condition of any vacuum degree, vacuum chamber can effectively suppress the explosion flame and overpressure; as vacuum degree changes, the effect of gas explosion suppression using vacuum chamber is slightly different. Vacuum chamber has obvious influence on propagation characteristics of the explosion flame. After explosion flame passes by vacuum chamber, the flame signal weakens, the flame thickness becomes thicker, and the flame speed slows down. With the increase of the vacuum degree of vacuum chamber, the flame speed can be prevented from rising early by vacuum chamber. The higher the vacuum degree is, the more obviously the vacuum chamber attenuates the explosion overpressure, the smaller the average overpressure is, and the better effect of the gas explosion suppression is. Vacuum chamber can effectively weaken the explosion impulse under each vacuum degree. From the beginning of −0.01 MPa, the vacuum chamber can gradually weaken explosion impulse as the vacuum degree increases, and the effect of gas explosion suppression gradually becomes better. When the vacuum degree is greater than −0.04 MPa, the increase of vacuum degree can make the explosion overpressure decrease but have little influence on the explosion impulse. Therefore, the vacuum chamber has the preferable suppression effect with equal to or greater than −0.04 MPa vacuum degree.     

不同边沿高度油池火燃烧行为的实验和数值模拟研究

采用实验和FDS数值模拟相结合的方法,探讨了边沿高度对油池火燃烧特性的影响。在实验部分,研究了燃烧速率和表观火焰高度随边沿高度的变化趋势,并分别分析了各个阶段的热反馈机制。在实验获得不同尺度、边沿高度正庚烷油池火燃烧速率的前提下,建立相应尺度的不同边沿高度油池火的Fire Dynamics Simulator(FDS)计算模型以针对火焰高度进行了数值模拟研究,分析了实际火焰高度、火焰下探高度随边沿高度的变化趋势,并提出了相关的无量纲拟合式。     

综合管廊内火灾自动报警探测器实验研究

为了能够有效提升综合管廊内火灾自动报警系统的准确性和可靠性,本文采用火灾实体试验的方法,通过对各类型火灾自动报警探测器响应时间的情况进行分析和比较,研究综合管廊电力舱内常用探测器的性能。研究结果表明:接触式缆式线型感温火灾探测器可以较早的探测到电缆温度异常变化的现象,可用于早期预警。点型感烟探测器对烟粒子浓度较为敏感,可用于综合管廊电力舱室的空间探测。分布式光纤型感温火灾探测器对明火温度的变化较为敏感,作为空间型的火灾探测器比较可靠。     

金属丝网对甲烷/空气预混火焰管道内传播的影响

为研究管道内金属丝网对甲烷/空气预混火焰传播的影响，通过实验和三维数值模拟研究安装金属丝网的管道内火焰传播特性以及流场、温度场的变化。结果表明:40目4层的金属丝网可以使火焰淬熄，30目4层的金属丝网无法淬熄，但可以使火焰停滞3 ms；大涡模型可以很好地对管道内火焰淬熄现象进行模拟；当火焰穿过30目4层金属丝网时，速度增大，在Kelvin Helmholtz不稳定和Rayleigh Taylor不稳定的耦合作用下形成湍流；金属丝网的目数会影响热量在丝网层中的扩散，当金属丝网为30目4层时，火焰热量扩散快，而当金属丝网为40目4层时，火焰热量扩散慢且温度大幅度衰减，衰减率达到83%。     

Research based on double coverage rate and reliability of gas detector layout optimization

The gas detector layout should be highly attuned to combustible gas leakage and attain a good reliability in avoiding detector malfunction, which is an important guarantee for the normal production of the chemical industry and other related enterprises. Herein, a gas detector layout optimization method based on double coverage and reliability is proposed. The key gas leakage monitoring area is determined through layout scene field investigation. To improve the detection probability and detection system reliability, the dual coverage target and voting mechanism are set, and the gas detector layout is determined with the ray-casting algorithm according to the coverage target. Combined with FLACS software to simulate a variety of typical leakage conditions under different layout scenarios, the relationship between the leaked gas concentration detected by gas detectors in each layout scheme and time is obtained, and the gas leakage detection probability in each layout scheme, number of detectors that can trigger the alarm, shortest time to trigger the alarm and reliability are comprehensively evaluated. The decision-maker selects the final gas detector layout plan according to the evaluation results and actual site needs. The study shows that the detection probability of each layout scheme set according to the double coverage is high, and multiple detectors can trigger the alarm (up to 100%), which ensures that the alarm can be triggered within 10 s under all applicable conditions. According to the evaluation results, the decision-maker can obtain a layout scheme that not only agrees with the actual site conditions but also attains a high detection probability, short detection time and strong reliability.     

木材在不同放置角度下火蔓延特性的实验研究

选用厚度为2 mm与3 mm的木材,研究了可碳化固体可燃物在静止氛围中不同角度下的火蔓延特性.研究表明,在不同角度范围内火蔓延经历着熄灭、稳定燃烧、加速燃烧以及快速燃烧等变化过程.对两种厚度的木材火蔓延行为对比分析发现,在自然对流条件下,两种厚度木材的火蔓延极限角度分别为-5°,5°.另外,研究了试样上下表面火焰参数与火蔓延速度之间的关系.在10°＜α＜60°范围内,火蔓延速度计算值与实验值能较好拟合.     

含磷酸盐对聚乙烯粉尘爆燃的抑制影响实验研究

为了揭示含磷酸盐（KH_{2PO4,NH4H2PO4,Ca(H2PO4)2）对聚乙烯粉尘爆炸的抑制作用,通过哈特曼管实验装置和20 L球形爆炸罐,研究含磷酸盐对聚乙烯粉尘爆炸火焰和压力传播特性的抑制效果。采用高速摄影方法记录含磷酸盐对聚乙烯粉尘爆炸火焰传播的影响;采用20 L球形爆炸罐,收集压力传感器数据,分析含磷酸盐对聚乙烯粉尘爆炸压力的影响;采用同步热分析仪研究聚乙烯粉尘和含磷酸盐的热解行为。研究结果表明:含磷酸盐对聚乙烯粉尘爆炸火焰传播特性参数和爆炸压力特性参数均有显著的影响,通过对比得到NH4H2PO4抑制效果相对最好。研究结果可为含磷酸盐在抑爆剂工程应用提供理论基础。}